Product ID:KS 7470,52002
MSDS Date:03/01/1998
FSC:9150
NIIN:00-448-5009
Status Code:A
MSDS Number: CHVTW

Emergency Phone: 732-389-5514

Info Phone: 201-589-0250/732-389-5514

Cage: 92895

Telephone: 201-589-0250

Cage: 92895

NJ TRADE SECRET # 00840600-5018P (NON-HAZARDOUS)

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

NJ TRADE SECRET # 00840600-5011P (NON-HAZARDOUS)

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE- EYES:
MAY CAUSE MILD IRRITATION. SKIN: PROLONGED/REPEATED CONTACT MAY
CAUSE MILD IRRITATION. INHALE: NOT LIKELY TO OCCUR. VAPORS (AT HIGH
TEMPERATURES)/MISTS MAY CAUSE RESPIRATORY IRRITATION. ORAL:
UNKNOWN.CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DISCOMFORT, TEARING, DRYNESS

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED: NOT NORMALLY
REQUIRED. REMOVE TO FRESH AIR IF EXPOSED. EYES: FLUSH WITH WATER,
HOLDING EYELIDS OPEN. SKIN: WASH WITH SOAP & WATER. ORAL: DO NOT
INDUCE VO MITING. CONSULT A PHYSICIAN.

Flash Point Method:COC
Flash Point:=204.4C, 400.F
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA FOR ENCLOSED OR CONFINED AREAS
Unusual Fire/Explosion Hazard:DO NOT USE DIRECT STREAM OF WATER,
MATERIAL MAY FLOAT AND REIGNITE

Spill Release Procedures:WEAR GLOVES. PROVIDE ADEQUATE VENTILATION.
REMOVE SPILL WITH INERT ABORBENT SUCH AS SAND, CLAY, EARTH.
TRANSFER TO PROPER CONTAINERS FOR DISPOSAL. PREVENT RUN-OFF TO
ENTER SEWERS OR WATERWAYS. REPORT SPILLS AS REQUIRED TO
AUTHORITIES.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE, IN A WELL
VENTILATED AREA, AWAY FROM INCOMPATIBLES. KEEP OUT OF REACH OF
CHILDREN. KEEP CONTAINER CLOSED.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. DO NOT TAKE
INTERNALLY. DO NOT EAT, DRINK OR SMOKE IN THE WORK AREA.

Respiratory Protection:NONE NORMALLY NEEDED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS, WEAR NIOSH-APPROVED
ORGANIC VAPOR AND MI ST RESPIRATOR (REFER TO 29 CFR 1910.134)
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:RUBBER FOR PROLONGED CONTACT
Eye Protection:SAFETY GLASSES RECOMMENDED
Other Protective Equipment:EYEBATH, WASHING FACILITY, UNIFORM
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A, B OR C, SAME
NSN.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>204.4C, 400.F
Vapor Pres:<0.1MM/GH
Spec Gravity:0.880
Evaporation Rate & Reference:<0.001(N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR YELLOW LIQUID - MILD ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG ALKALIS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:INCINERATE OR DISPOSE OF IN COMPLIANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.